2005 Toyota Tacoma Transmission 5 & 6 Speed Manual

Equip cars, trucks & SUVs with 2005 Toyota Tacoma Manual Transmission from AutoZone. Get Yours Today! We have the best products at the right price. Aug 19, 2016  It will show me test driving the new Toyota Tacoma manual transmission double cab and show you what clutch start cancel is really supposed to be used for. 2016 Toyota Tacoma TRD Offroad (6.

1. 2005 Tacoma Transmission Problems
2. 2005 Toyota Tacoma Transmission Replacement
3. Toyota Tacoma Automatic Transmission
4. 2005 Toyota Tacoma Transmission Service

Eight problems related to manual transmission have been reported for the 2005 Toyota Tacoma. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Toyota Tacoma based on all problems reported for the 2005 Tacoma.

This is a follow up to a previous complaint regarding difficulty shifting particularly from 1st to 2nd. After sending three certified letters to Toyota (the last sent to the president's office) I finally, more than 6 months later, received a written response. Perhaps because of the reasons I cited for my failed mediation attempt (in particular being given bad advice, which, at the time, I naively accepted, by the Toyota factory trained specialist on how to prepare for the mediation) I was granted a second attempt at mediation. The transmission continues to behave in the fashion I previously mentioned. I simply cannot understand why it is 'normal' for the gears to intermittently clash (and the colder it is, grind) when shifting. I have been driving 5 speeds for more than 2 decades.

My 2005 Tacoma has had a clutch squeal since it was brand new. Toyota has replaced 2 clutches after 2 release bearing failures in less then 1 years time. After the second clutch the squeal came back within 3,000 miles. The dealer lubed the slave cylinder / clutch fork intersection point. After several trips from 48 hrs to 1 month intervals they lubed it numerous times. Fed up I informed them I would not be coming in constantly to have the transmission lubed. They replaced the slave cylinder and clutch fork. Within 48 hrs the squeal was back. After having the vehicle in for a Toyota field tech to look at the replaced the clutch return spring. Within 24 hours the squeal was back. During all the incidents I contacted Toyota to keep them informed of the issues. The latest call resulted in escalation as I have requested replacement of the transmission as there is apparently a defect in the casting of the transmission or an internal issue. Toyota called me back to say they would work out a plan with my dealer to fix the vehicle. (this is after 13 trips to the dealer for the same problem between repairs and lube trips. ) I was informed I would be called back no later then Thursday Nov 14th. As of this point there has been no contact and I'm taking legal actions.

When shifting from 1st to 2nd, there is an inconsistent and unpredictable mechanical sensation that varied from a mild yet distinct rough transition (creating the perception that I was forcing the gears) to a dramatic mechanical sensation of gears changing (at times accompanied with a clicking sound). I returned to the dealership to have the master technician (mt) drive the truck and see if he was experiencing what I was experiencing. He shared that he could feel the gears and said he could replace the transmission if the factory trained specialist (fts) agreed it needed replacing. Fts drove the truck with me and did not feel that there was anything abnormal about the shifting (vehicle operates as designed. . . ). Because the present shifting sensation makes you feel like you are forcing or grinding gears when shifting from 1st to 2nd, this is a safety issue given I can tend to be more focused on the shifting from 1st to 2nd than on driving and it is uncertain whether the transmission will possibly fail while I am driving the truck. I have owned at least 5 or 6 five-speed vehicles. I have also worked on transmissions. In all my experience with 5-speeds I have owned, I have never experienced a shifting problem like I am presently experiencing. This is a brand new, supposedly, quality Toyota vehicle and it unquestionably seems that something is not right with the transmission. I am currently in arbitration.

I have a 2005 Toyota Tacoma trd 4x4 they have replaced my front wheel bearings 6 times know my front diff, the transmission once and my rear end.

During recent cold winter weather, had couple incidents where brakes appeared to not operate correctly on moderate ice/slushy road condition and this caused on one occasion to run through intersection due to not being able to stop the vehicle being fortunate that no other traffic was present at the time. This all comes after a transmission replacement at 6271 miles and rear brake work on the vehicle at 6558 miles. This truck is like a lemon.

At around 6150 miles, transmission was making a clicking sound and occasional issues encountered getting the vehicle to shift into 1st gear. Took vehicle into dealership and they identified that bearing had slipped loose in transmission. Dealer ordered and installed a brand new transmission into 2005 Toyota Tacoma pick up.

The contact owns a 2005 Toyota Tacoma with manual transmission. The contact stated that when driving at any rate of speed in fourth gear, the transmission would intermittently switch into neutral without warrant. When placed back into fourth gear, the vehicle would function as normal until the failure would recur. The contact stated he would experience the failure at least once each time the vehicle was operated. The dealer advised the vehicle was not under recall and would not offer any assistance. The contact parked the vehicle and was no longer operating it. The failure mileage was approximately 1,000 and the current mileage was approximately 15,000.

My 2005 Toyota Tacoma used to lunge forward and accelerate while stopped. It happened over the several years I owned it. I reported this to the dealer and they ignored me. I would always make sure I had the brake depressed hard while stopped.

Toyota Tacoma owners have reported 24 problems related to manual transmission (under the power train category). The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Toyota Tacoma based on all problems reported for the Tacoma.

2010 Tacoma 4cyl, 5 speed. Clutch started slipping during acceleration in 4th gear. First occurance happened at 10700 miles. Truck now has 13500 miles and the issue has gotten worse. Vehicle has been to the dealer 3 times for resolution. Service department says they can't duplicate and refuse to do anything else. Slipping occurs in every gear except 1st. Dangerous when trying to accelerate to merge into traffic. Rpm's surge but the vehicle does not accelerate.
See all problems of the 2010 Toyota Tacoma .

2001 Toyota Tacoma replaced rear axle bearing twice already truck has less 90000 miles. In both incidents it has ruined the internal parts of the axles causing damage to the carrier case. I bought a 3 rd trd axle at a wrecking yard to find the same problem in that axle. I was fortunate I was not involved in a accident. The rear axle could of locked up on the highway causing a serious accident or death related to axle failure.
See all problems of the 2001 Toyota Tacoma .

Ref: NHTSA 96e00100ref: Toyota referred recall website <. . Read more..
See all problems of the 1996 Toyota Tacoma .

Vehicle is a 2010 Toyota Tacoma dbl cab, the transmission searches for the right gear to accelerate in once the speed gets 15mph or lower and you press the gas peddle. At 1st it was just annoying, but recently I was turning a corner at a signal light behind another veh. And it slammed on it's brakes, I went to go into the passing lane, but when I accelerated, the transmission didn't respond, it just revs up trying to find the gear. By the time it did, I was watching in my mirror and an oncoming vehicle started hitting their brakes to avoid hitting me. Which wouldn't have been an issue if my truck would have gone when I pressed the gas. This occurs every time you are going at a rate over 25 mph and slow down to at least 15 mph and then try to accelerate again. Crossing highways. I purchased this truck oct. 21, 2009 and had it back to the dealership on Nov 9th, 2009 with this issue, the tech drove it, acknowledged it, and told me all the newer vehicles are that way, & have had others come in with the same issue. Nothing else has been done to try to fix this. I believe this could lead to potential accidents and injuries, if not worse.

The contact owns a 2006 Toyota Tacoma. Whenever the contact attempted to switch gears from 4th to 5th he noticed that the rpm's would remain constant or rise for a period of 10 seconds. The failure occurred at various speeds. The vehicle was taken to the dealership where the contact was informed that the vehicle was working properly. The contact has noticed the failure since the day the vehicle was purchased. The failure mileage was 26,041 updated 4/26/10the consumer stated during 4th and 5th shifting, the accelerator pedal would stick. He also experienced erratic idling while in 1st gear. The throttle would stick from 8-14 seconds. Updated 08/24/10.
See all problems of the 2006 Toyota Tacoma .

In December of 2008, I purchased a brand new 2009 Toyota Tacoma from harr Toyota for about $30,000. This truck was a 4x4 off road, and came with all of the extra options that could be offered. The truck included a 36,000 mile bumper to bumper warranty and a lifetime power train warranty. Since I travel often for work, the truck would remain garaged for the next few months, away from the elements of the winter. In July, after returning from a business trip, I started to notice that on the highway, the truck had an unusual odor, and when the gas pedal was applied, the smell would get worse. I brought the truck in to be looked at by harr Toyota service department, where the transmission was immediately refused to be covered under warranty due to corrosion. ¿ historically, Toyota has had many issues with corrosion and the immediate refusal for coverage shocked me. They claimed that the truck appeared to have been driven through a body of salt water coincidentally on the transmission only. After repeated attempts to get Toyota corporate to review my case, they claimed that they came to see the truck, and denied coverage. As my research showed, they had not actually come down, and had just spoken to the dealership on the phone. On the next attempt at a Toyota inspection for coverage, it was determined that I had to pay $441. 00 for them to take the transmission down, and then coverage was once again denied. . After numerous calls, and insulting conversations with demeaning and sarcastic customer care representatives, I have given up and feel that Toyota may have gotten the best of me.
See all problems of the 2009 Toyota Tacoma .

2009 Tacoma 4 cyl. 5 speed manual trans 4 x4. Clutch started slipping at 5000 miles, at 15,000 slipping badly. Brought to dealer who refused to recognize the problem as a warranty issue. Dealer wanted authorization for repair costs of $480 -$1000 before they would disassemble and inspect the vehicle to determine if a defect exists. Dealer is looking for a blank check, only to call the defect a wear issue and charge customer for repair rather than accept a lower warranty reimbursement from Toyota. Driver has had 4 previous Toyotas and all had manual transmissions . Vehicles logged between 161,000 and 191,000 miles and never needed a clutch replacement.

In extreme cold temps, single digits or below zero, the clutch will not return or returns very slowly. Returned to dealer for service and did not find any problems. They advised to return when temp is colder.
See all problems of the 2007 Toyota Tacoma .

A chirping sound began being emitted from the transmission. The chirp was present at all times except when the clutch was depressed. The problem was diagnosed as a throw out bearing wiggling on the pilot shaft. The throw out bearing scored the pilot shaft. A new throw out bearing was installed and the pilot shaft smoothed with emory cloth. This solution solved the problem immediately, but within a year, the same chirp returned. The throw out bearing is again vibrating on the pilot shaft.

This is a follow up to a previous complaint regarding difficulty shifting particularly from 1st to 2nd. After sending three certified letters to Toyota (the last sent to the president's office) I finally, more than 6 months later, received a written response. Perhaps because of the reasons I cited for my failed mediation attempt (in particular being given bad advice, which, at the time, I naively accepted, by the Toyota factory trained specialist on how to prepare for the mediation) I was granted a second attempt at mediation. The transmission continues to behave in the fashion I previously mentioned. I simply cannot understand why it is 'normal' for the gears to intermittently clash (and the colder it is, grind) when shifting. I have been driving 5 speeds for more than 2 decades.
See all problems of the 2005 Toyota Tacoma .

My 2005 Tacoma has had a clutch squeal since it was brand new. Toyota has replaced 2 clutches after 2 release bearing failures in less then 1 years time. After the second clutch the squeal came back within 3,000 miles. The dealer lubed the slave cylinder / clutch fork intersection point. After several trips from 48 hrs to 1 month intervals they lubed it numerous times. Fed up I informed them I would not be coming in constantly to have the transmission lubed. They replaced the slave cylinder and clutch fork. Within 48 hrs the squeal was back. After having the vehicle in for a Toyota field tech to look at the replaced the clutch return spring. Within 24 hours the squeal was back. During all the incidents I contacted Toyota to keep them informed of the issues. The latest call resulted in escalation as I have requested replacement of the transmission as there is apparently a defect in the casting of the transmission or an internal issue. Toyota called me back to say they would work out a plan with my dealer to fix the vehicle. (this is after 13 trips to the dealer for the same problem between repairs and lube trips. ) I was informed I would be called back no later then Thursday Nov 14th. As of this point there has been no contact and I'm taking legal actions.

When shifting from 1st to 2nd, there is an inconsistent and unpredictable mechanical sensation that varied from a mild yet distinct rough transition (creating the perception that I was forcing the gears) to a dramatic mechanical sensation of gears changing (at times accompanied with a clicking sound). I returned to the dealership to have the master technician (mt) drive the truck and see if he was experiencing what I was experiencing. He shared that he could feel the gears and said he could replace the transmission if the factory trained specialist (fts) agreed it needed replacing. Fts drove the truck with me and did not feel that there was anything abnormal about the shifting (vehicle operates as designed. . . ). Because the present shifting sensation makes you feel like you are forcing or grinding gears when shifting from 1st to 2nd, this is a safety issue given I can tend to be more focused on the shifting from 1st to 2nd than on driving and it is uncertain whether the transmission will possibly fail while I am driving the truck. I have owned at least 5 or 6 five-speed vehicles. I have also worked on transmissions. In all my experience with 5-speeds I have owned, I have never experienced a shifting problem like I am presently experiencing. This is a brand new, supposedly, quality Toyota vehicle and it unquestionably seems that something is not right with the transmission. I am currently in arbitration.

The clutch on my 2003 Toyota Tacoma became jammed while trying to shift in the middle of an intersection. The bushing where the clutch pivots dislodged and jammed the clutch so it was unable to be depressed. A car was coming straight into the side of my vehicle when I stomped on the clutch as hard as I could, breaking the bushing and letting the clutch depress. If I had not acted quickly it could have been a fatal accident. This was on a highway intersection. I took it in to Toyota and they did not tell me the bushing had broke and was missing they just put grease on it so it would stop squeaking. I just found out this year at Toyota that the bushing had exploded and fallen out and now the warranty has expired. I am more concerned about someone else being stuck in a situation and not being able to get their vehicle in gear.
See all problems of the 2003 Toyota Tacoma .

I purchased a Toyota Tacoma 2006 new and from day one had problems with the vehicle over revving on start up, which is very damaging to an engine in cold climates. It also between shifting from 3rd to 4th, and 4th to 5th gears the rpm's will not come down to enable one to shift properly and not only makes for a road dangerous condition but it also causes damage to the entire drive train. I've been unsuccessful at trying to take care of this problem with Toyota, quite frankly they have a very bad attitude with this whole matter and to give you an example, I was told by one dealership that maybe I should learn how to shift faster. Please assist me .

I have a 2005 Toyota Tacoma trd 4x4 they have replaced my front wheel bearings 6 times know my front diff, the transmission once and my rear end.

2005 Tacoma Transmission Problems

During recent cold winter weather, had couple incidents where brakes appeared to not operate correctly on moderate ice/slushy road condition and this caused on one occasion to run through intersection due to not being able to stop the vehicle being fortunate that no other traffic was present at the time. This all comes after a transmission replacement at 6271 miles and rear brake work on the vehicle at 6558 miles. This truck is like a lemon.

Engine rpm hangs when shifting from 4th to 5th gear,clutch has long delay to engagement in sub-zero temp. Dealer says these are normal.

2005 Toyota Tacoma Transmission Replacement

At around 6150 miles, transmission was making a clicking sound and occasional issues encountered getting the vehicle to shift into 1st gear. Took vehicle into dealership and they identified that bearing had slipped loose in transmission. Dealer ordered and installed a brand new transmission into 2005 Toyota Tacoma pick up.

1 parked with truck in 1st gear2 truck came out of gear 2 times. I stoped the truck 1 time, a tree stopped it the 2nd time. 1 year later, the truck pops into nutural while driving. I put it back in gear, I sometimes hold the shifter to keep it in gear. 3 I have not tryed to fix the transmission, but I always set the parking break.
See all problems of the 1997 Toyota Tacoma .

The contact owns a 2005 Toyota Tacoma with manual transmission. The contact stated that when driving at any rate of speed in fourth gear, the transmission would intermittently switch into neutral without warrant. When placed back into fourth gear, the vehicle would function as normal until the failure would recur. 2007 hyundai accent owners manual download. The contact stated he would experience the failure at least once each time the vehicle was operated. The dealer advised the vehicle was not under recall and would not offer any assistance. The contact parked the vehicle and was no longer operating it. The failure mileage was approximately 1,000 and the current mileage was approximately 15,000.

My 2005 Toyota Tacoma used to lunge forward and accelerate while stopped. It happened over the several years I owned it. I reported this to the dealer and they ignored me. I would always make sure I had the brake depressed hard while stopped.

Date of purchase Toyota of somerset reported this was a second buyer. They reported a lady had owned the vehicle. Through carfax I found me to be the 5th owner. They did not have the warranty information in with the manual information. They did not supply this at time of purchase and has not offered upon request. They said they would honor the service. Upon the reverse coming out there was disagreement and the service manager, mr. Turpin and mr. Johnson were very adamant and refused to honor the mfg. Warranty on the drive train. They first asked $700 and then negotiated for $450. Which I refused. Needless to say we do not have any correspondence but I still have to drive without reverse in my vehicle. This is why I did not report the lug nuts breaking and causing my wheel to fall off and causing damage to the truck. Toyota of somerset does not offer assistance and accuses abuse.

At approximately 60 mph, heard a thud sound and lost all gears except for 4th gear.

When accelerating in 2nd gear there is a bad vibration(2000-2500 rpm). It also 'clunks' when shifting from 1st gear to 2nd gear. The higher the rpm the worse it 'clunks'. Vehicle purchased in November 1999. Taken to dealer twice regarding problem. Dealer says it is 'normal'. I am concerned that the transmission synchronizers are worn out and want to get problem resolved while covered under 60,000 mile drivetrain warranty.
See all problems of the 1998 Toyota Tacoma .

Find everything you need to know about your 2016 Toyota Corolla in the owners manual from Toyota Owners. Toyota Owners. Truck or SUV. Or, get the Toyota Manual for your Toyota ride free of charge using our Toyota Owners manual free download option. To view or download additional manuals that take you down to the nuts and bolts of most. 2016 toyota corolla car manual. View and Download Toyota Corolla 2016 owner's manual online. Corolla 2016 Automobile pdf manual download. Also for: 2016 corolla. What does my Toyota warranty cover? Learn more about your Toyota warranty plus use the Toyota Owners Manual free download tool to find the right Toyota manual for your car. Join Toyota Owners today to stay updated on all the most recent Toyota manuals and warranty information.

Toyota Tacoma Automatic Transmission

2005 Toyota Tacoma Transmission Service